Organizations: Future Robotics Technology Center (fuRo), Chiba Institute of Technology, Narashino, Chiba, Japan.
Abstract
Legged-wheeled robots have long been studied for their potential to combine the efficient flat-ground mobility of wheels with the rough-terrain capability of legs. However, examples of their application to long-range autonomous navigation in real environments remain limited. This paper reports our effort to build a deep reinforcement learning (DRL) based locomotion controller and an autonomous navigation system for the commercially available legged-wheeled robot Go2-W, and to apply them to long-range autonomous navigation in a real environment. For locomotion control, we extended a proprioception-only policy, which we had previously developed for quadruped robots, to the 16-DoF legged-wheeled robot. We also found that wheeled locomotion concentrates the load on the hip joints and causes heat concentration that hinders sustained travel, and obtained a policy that suppresses it by distributing the load. We evaluated the system at the Tsukuba Challenge 2025, demonstrating that it can autonomously traverse an approximately 2.8 km route including sidewalks, a park, and stairs without stopping due to overheating.
Deep reinforcement learning has shown strong potential for robot navigation, but its practical deployment is still limited by the long wall-clock cost of policy training. This paper presents FlashNav, a GPU-first framework for ultra-fast range-based robot navigation training. To the best of our knowledge, FlashNav is the first DRL-based robot navigation framework that reaches seconds-level policy training, with the fastest deployable policy trained in less than 20 seconds. The key idea is to align simulation with the navigation MDP: FlashNav preserves the essential components for velocity-level navigation, including occupancy geometry, range sensing, goal-conditioned control, robot motion dynamics, collision handling, termination, and reset, while removing unnecessary rendering and high-fidelity physical details from the training loop. Built on a batched bitmap simulator and a fully GPU-resident training pipeline with our FastDSAC learner, FlashNav generates massive parallel navigation transitions entirely on GPU. Experiments on TurtleBot2 and Unitree Go2 show that FlashNav achieves a 100% success-rate below 20 seconds on an RTX 5090 and remains within tens of seconds across desktop GPUs. The learned policies further transfer to physical wheeled and legged robots in static and dynamic indoor scenes, demonstrating that DRL-based navigation can be trained at seconds-level speed while preserving deployable obstacle-avoidance behavior.
Motor thermal management is often overlooked in the context of electrically-actuated robots, particularly legged robots, but motor overheating is a key factor that limits long-duration locomotion especially under payload conditions. This paper integrates a whole-body thermal model of a quadruped robot into the reinforcement learning pipeline to update motor temperatures, and proposes a two-stage training framework for motor thermal management. In this framework, a nominal policy is first pre-trained as a locomotion baseline capable of traversing diverse terrains. A residual policy is then trained on top of the nominal policy to provide corrective actions based on the robot's thermal state, ensuring high performance under low-temperature conditions and preventing motor overheating under high-temperature conditions. Simulation results demonstrate that the proposed policy achieves an effective balance between motor thermal safety and locomotion performance. Real-world experiments on a Unitree A1 quadruped robot further validate the approach: under a 3 kg payload, the robot achieves stable locomotion across multiple terrains for over 13 minutes, while the nominal policy alone leads to motor overheating in about 5 minutes.
Reinforcement learning (RL) for legged robots is advancing locomotion, demonstrating its ability to adapt to new and challenging terrain. Traditionally, these RL locomotion frameworks are position-based, making the policy less adaptable to terrain types and requiring state estimation techniques in the observation space, i.e., linear velocity. Moreover, these RL frameworks often use small, lightweight quadrupeds that are limited in their viability for high-complexity tasks due to hardware constraints. This work explores an RL torque control framework for heavyweight high-torque quadrupeds. The RL framework in this paper can traverse rough terrain and effectively track a desired linear velocity without requiring knowledge of the agent's current velocity. Using Nvidia's Isaac Sim and Isaac Lab, simulation results of the RL torque control policy are shown on the Unitree B1 quadruped, achieving speeds of 3.5 m/s and 1.5 rad/s. In addition, the quadruped can walk up and down stairs without the aid of an exteroceptive sensor.